Study on Antifungal Effect and Composition of Ultraviolet on Nutritional Wastewater

doi:10.13304/j.nykjdb.2022.1075

Abstract

Abstract:

To evaluate the antifungal effect of Fusarium oxysporum and composition of ultraviolet irradiation on nutritional wastewater， taking 2 typical fungi， Fusarium oxysporium f.sp. Cucumerinum and Fusarium oxysporum f.sp.Lycopersici as materials， and the sterilization experiment of nutrient wastewater was conducted， which 3 different levels of irradiation intensity according to 1.3， 2.7， 3.8 mW·cm^-2， and 3 irradiation time applications including 1， 3， 5 min were carried out. The results showed that， UV irradiation had obvious antifungal effect on 2 kinds of pathogenic fungi in vitro culture， and with the increase of irradiation dose， the mycelium grew slowly， the colony morphology shrank， the spore reproduction and the germination rate decreased， and 100% sterilization rate was achieved at the highest dose of 1 140 mJ·cm^-2 （3.8 mW·cm^-2， 5 min）. Similarly， the highest dose treatment under the inoculated nutrient solution significantly inhibited the growth of spores and reached a killing rate of more than 95%. In addition， after the highest dose of UV irradiation， the removal rates of organic matter in the 2 nutrient solutions were 92.3% and 83.3%， respectively， while the contents of total nitrogen and total phosphorus did not change significantly， which indicated that while UV irradiation could effectively disinfect， it would easily trigger the loss of organic matter in nutrient solution and affect its subsequent recycling. Above results provided basic data for the application of ultraviolet sterilization technology in the circulation system of facility horticulture.

Key words: ultraviolet irradiation, nutritional wastewater, Fusarium oxysporum, antifungal effect, nutrient composition

摘要：

为探究紫外线辐照对栽培营养废液中尖孢镰刀菌的抑菌效果以及营养成分的影响，以2种典型真菌即黄瓜和番茄专化型尖孢镰刀菌为材料，采用1.3、2.7、3.8 mW·cm^-2 3种辐照强度和1、3、5 min 3个辐照时间对营养废液进行灭菌试验。结果表明，在离体培养下，紫外线对2种病原真菌有明显抑制效果，且随着辐照剂量增加，菌丝生长缓慢，菌落形态皱缩，孢子生殖量及萌发率降低，在最高剂量1 140 mJ·cm^-2（3.8 mW·cm^-2、5 min）下实现100%抑菌率；同样在接种营养液下最高剂量处理显著抑制菌孢生长，杀灭率达到95%以上。经最高剂量紫外辐照后2种营养液中有机物去除率分别为92.3%、83.3%，而全氮、全磷含量无明显变化，表明紫外辐照在实现有效抑菌的同时易造成营养液中有机质损失而影响其后续的循环利用。以上研究结果为紫外杀菌技术在设施园艺栽培循环系统的应用提供基础数据。

关键词: 紫外辐射, 营养废液, 尖孢镰刀菌, 抑菌作用, 营养成分

CLC Number:

S436.3

Chongtao LIU, Tong LI, Yangyang LI, Zhuangzhuang LIU, Yangyang CAI, Jianchao SONG, Wantong ZHANG, Bin SHANG, Xiuping TAO. Study on Antifungal Effect and Composition of Ultraviolet on Nutritional Wastewater[J]. Journal of Agricultural Science and Technology, 2024, 26(7): 166-173.

刘崇涛, 李同, 李洋洋, 刘壮壮, 蔡阳扬, 宋建超, 张万通, 尚斌, 陶秀萍. 紫外线对栽培营养废液的抑菌效应及营养成分影响研究[J]. 中国农业科技导报, 2024, 26(7): 166-173.

Figures/Tables 7

References 29

1	李东星,田真,王浚峰,等.植物工厂营养液循环再利用装备的研究应用[J].农业工程,2011,1(1):46-51.
	LI D X, TIAN Z, WANG J F, et al.. Research and application on a nutrient recycle equipment [J]. Agric. Eng., 2011,1(1):46-51.
2	陈磊夫,刘志雄,吴金平,等.蔬菜无土栽培营养液灭菌除藻研究进展[J].中国蔬菜,2020(7):24-29.
	CHEN L F, LIU Z X, WU J P, et al.. Research progress on disinfection and algae removing by nutrient solution in soilless vegetable culture [J]. China Veget., 2020(7): 24-29.
3	刘向辉,刘芬,周立刚,等.紫外线杀灭营养液中黄瓜枯萎病病菌试验研究[J].中国农学通报,2005,21(3):268-271.
	LIU X H, LIU F, ZHOU L G, et al.. UV disinfection of fusarium oxysporium f.sp.cucumerinum in drain water from closed system [J]. Chin. Agric. Sci. Bull., 2005,21(3): 268-271.
4	DEAN R, VAN KAN J A, PRETORIUS Z A, et al.. The top 10 fungal pathogens in molecular plant pathology [J]. Mol. Plant Pathol., 2012,13(4): 414-430.
5	高晓敏,王琚钢,马立国,等.尖孢镰刀菌致病机理和化感作用研究进展[J].微生物学通报,2014,41(10):2143-2148.
	GAO X M, WANG J G, MA L G, et al.. Research advances on the mechanism of pathogenesis and allelopathy of Fusarium oxysporium [J]. Microbiol. China, 2014,41(10): 2143-2148.
6	MA L J, GEISER D M, PROCTOR R H, et al.. Fusarium pathogenomics [J]. Annu. Rev. Microbiol., 2013,67(1): 399-416.
7	RUNIA W T, AMSING J J. Disinfection of recirculation water from closed cultivation systems by heat treatment [J]. Acta Hortic., 2001,548(1): 215-222.
8	徐燕,赵春燕,孙军德.臭氧对无土栽培营养液的消毒作用研究[J].微生物学杂志,2004,24(6):60-61.
	XU Y, ZHAO C Y, SUN J D. Sterilization of nutritive solution for soilless cultivation by ozone [J]. J. Microbiol., 2004,24(6): 60-61.
9	宋卫堂,孙广明,刘芬,等.臭氧杀灭循环营养液中三种士传病原菌的试验[J].农业工程学报, 2007,23(6): 189-193.
	SONG W T, SUN G M, LIU F, et al.. Ozone disinfection of three soilborne pathogens in nutrient solution [J]. Trans. Chin. Soc. Agric. Eng., 2007,23(6): 189-193.
10	刘超,宋卫堂,杨琪,等.灌溉臭氧水对生菜抗性生理的影响[J].山西农业大学学报(自然科学版),2016,36(5):327-331.
	LIU C, SONG W T, YANG Q, et al.. The effects of ozone water irrigation on the resistant physiology of lettuce [J]. J. Shanxi Agric. Univ. (Nat. Sci.), 2016,36(5): 327-331.
11	宋卫堂,袁小艳,王冬华,等.营养液加热消毒机的设计与灭菌性能试验[J].农业工程学报,2007,23(5):111-115.
	SONG W T, YUAN X Y, WANG D H, et al.. Design and disinfection performance test of a heating installation for nutrient solution from closed system [J]. Trans. Chin. Soc. Agric. Eng., 2007,23(5): 111-115.
12	GÓMEZ M, PLAZA F, GARRALÓN G, et al.. A comparative study of tertiary wastewater treatment by physico-chemical-UV process and macrofiltration-ultrafiltration technologies [J]. Desalination, 2007,202(1-3): 369-376.
13	SANZ E N, DÁVILA I S, BALAO J A, et al.. Modelling of reactivation after UV disinfection: effect of UV-C dose on subsequent photoreactivation and dark repair [J]. Water Res., 2007,41(14): 3141-3151.
14	马万征,但琼鹏,马万敏,等.温室营养液循环利用装置及消毒效果研究[J].东北农业科学,2019,44(1):52-56.
	MA W Z, DAN Q P, MA W M, et al.. Research on the recycling device and disinfection effect of greenhouse nutrient solution [J]. J. Northeast Agric. Sci., 2019,44(1): 52-56.
15	宋卫堂,王成,侯文龙.紫外线-臭氧组合式营养液消毒机的设计及灭菌性能试验[J].农业工程学报,2011,27(2):360-365.
	SONG W T, WANG C, HOU W L. Development and test of nutrient solution disinfection machine by combining UV with ozone [J]. Trans. Chin. Soc. Agric. Eng., 2011,27(2): 360-365.
16	TSUNEDOMI A, MIYAWAKI K, MASAMURA A, et al.. UVA‐LED device to disinfect hydroponic nutrient solution [J]. J. Med. Invest., 2018,65(3.4): 171-176.
17	贾沛莉,陈诗雯,代瑞华.紫外线辐照技术去除藻类的研究进展[J].水资源保护,2017,33(5):138-144.
	JIA P L, CHEN S W, DAI R H. Research progress of removing algae by ultraviolet irradiation [J]. Water Resour. Prot., 2017,33(5): 138-144.
18	SAKAI H, OGUMA K, KATAYAMA H, et al.. Effects of low or medium-pressure UV irradiation on the release of intracellular microcystin [J]. Water Res., 2007,41(15): 3458-3464.
19	郭美婷,胡洪营,刘文君.复活光照强度对再生水紫外线消毒后大肠杆菌和粪大肠杆菌光复活的影响[J].环境科学,2008,29(9):2576-2579.
	GUO M T, HU H Y, LIU W J. Effect of photoreactivating light intensity on photoreactivation of Escherichia coli and Fecal coliform in the tertiary effluent disinfected by UV [J]. Environ. Sci., 2008,29(9): 2576-2579.
20	郑荣进,向坤,朱松明.紫外线对水产养殖循环水的杀菌效果[J].农业工程学报, 2011,27(11):257-262.
	ZHENG R J, XIANG K, ZHU S M. Bacterial inactivation effect of UV in aquaculture recirculating water [J]. Trans. Chin. Soc. Agric. Eng., 2011,27(11): 257-262.
21	张玮,肖梦婷,黄敏,等.短波紫外线辐照对灰葡萄孢抑菌机理的影响[J].北方园艺,2020(18):7-13.
	ZHANG W, XIAO M T, HUANG M, et al.. Effects of UV-C irradiation on antifungal mechanism of Botrytis cinerea [J]. Northern Hortic., 2020(18): 7-13.
22	刘玲,王旭,张培光,等.大蓟总黄酮对尖孢镰刀菌甜瓜专化型生长、生理的影响及其田间防治效果[J].植物保护学报,2020,47(3):628-636.
	LIU L, WANG X, ZHANG P G, et al.. Inhibition of total flavonoids in Cirsium japonicum DC on growth physiological indexes and control effect of Fusarium oxysporum f. sp. melonis in field [J]. J. Plant Prot., 2020, 47(3): 628-636.
23	宗兆锋,王汝贤,杨之为,等.紫外线对非致病尖孢镰刀菌的诱变作用[J].西北农林科技大学学报(自然科学版), 1996,24(2): 99-101.
	ZONG Z F, WANG R X, YANG Z W, et al.. Mutagenic effect of UV light on nonpathogenic Fusarium oxysporum [J]. J. Northwest A & F Univ. (Nat. Sci.), 1996,24(2): 99-101.
24	HAO K Y, ZHANG N, LI Y W, et al.. Effect of ultraviolet radiation on nitrogen and phosphorus removal from sewage in plateau environment [J]. Desalin. Water Treat., 2021,216(1): 232-238.
25	姜妍,蒋林时,苗时雨,等.紫外-Fenton法处理高盐有机废水[J].环境工程学报,2016,10(5):2349-2354.
	JIANG Y, JIANG L S, MIAO S Y, et al.. Treatment of high-salinity organic wastewater by ultraviolet-Fenton process [J]. Chin. J. Environ. Eng., 2016,10(5): 2349-2354.
26	张淼,李文涛,连军锋,等.紫外/氯工艺去除煤化工高盐废水中有机物的研究[J].中国给水排水,2021,37(21):82-88.
	ZHANG M, LI W T, LIAN J F, et al.. UV/chlorination process for the removal of organics in high salinity wastewater from coal chemical industry [J]. China Water Wastewater, 2021,37(21): 82-88.
27	邹海明,王艳,李飞跃,等.臭氧紫外组合工艺协同深度处理染料废水实验研究[J].工业水处理,2014,34(9):61-63.
	ZOU H M, WANG Y, LI F Y, et al.. Experimental research on the ozone-ultraviolet combined process for the advanced treatment of dye wastewater [J]. Ind. Water Treat., 2014,34(9): 61-63.
28	尤俊豪,郭明哲,宗永臣,等.紫外线照射对高原污水处理的影响[J].环保科技,2022,28(3):14-19.
	YOU J H, GUO M Z, ZONG Y C, et al.. Impact of UV irradiation on highland wastewater treatment [J]. Environ. Prot. Technol., 2022,28(3): 14-19.
29	江映翔,孙珮石,刘安文,等.紫外线辐射对活性污泥除磷性能的增强作用[J].中国环境科学,2003,23(2):184-188.
	JIANG Y X, SUN P S, LIU A W, et al.. Enhancement of phosphorus removal property of activated sludge with UV ray irradiation [J]. China Environ. Sci., 2003,23(2): 184-188.

紫外强度 Ultraviolet intensity/（mW·cm^-2）	照射时间 Irradiation time/min	产孢量 Sporulation yield/（10³ CFU·mL^-1）	孢子萌发率 Spore germination rate/%
U1.3	T1	12.62 a	82.5 a
	T3	9.71 b	57.8 b
	T5	4.85 d	30.7 c
U2.7	T1	9.51 b	62.0 b
	T3	5.65 cd	27.3 c
	T5	0.46 e	2.2 d
U3.8	T1	5.82 c	33.3 c
	T3	0.84 e	0.8 d
	T5	0.00 e	0.0 d
紫外强度U		**	**
照射时间T		**	**
紫外强度×照射时间 U×T		**	**

紫外强度 Ultraviolet intensity/（mW·cm^-2）	照射时间 Irradiation time/min	产孢量 Sporulation yield/（10³ CFU·mL^-1）	孢子萌发率 Spore germination rate/%
U1.3	T1	12.62 a	82.5 a
	T3	9.71 b	57.8 b
	T5	4.85 d	30.7 c
U2.7	T1	9.51 b	62.0 b
	T3	5.65 cd	27.3 c
	T5	0.46 e	2.2 d
U3.8	T1	5.82 c	33.3 c
	T3	0.84 e	0.8 d
	T5	0.00 e	0.0 d
紫外强度U		**	**
照射时间T		**	**
紫外强度×照射时间 U×T		**	**

紫外强度 Ultraviolet intensity/（mW·cm^-2）	照射时间 Irradiation time/min	产孢量 Sporulation yield/（10³ CFU·mL^-1）	孢子萌发率 Spore germination rate/%
U1.3	T1	13.35 a	88.5 a
	T3	10.75 b	61.3 b
	T5	6.63 e	30.3 cd
U2.7	T1	11.50 b	65.0 b
	T3	7.95 d	27.9 d
	T5	1.17 f	6.1 e
U3.8	T1	8.95 c	35.1 c
	T3	1.41 f	3.3 ef
	T5	0.00 g	0.0 f
紫外强度U		**	**
照射时间T		**	**
紫外强度×照射时间 U×T		**	**

紫外强度 Ultraviolet intensity/（mW·cm^-2）	照射时间 Irradiation time/min	产孢量 Sporulation yield/（10³ CFU·mL^-1）	孢子萌发率 Spore germination rate/%
U1.3	T1	13.35 a	88.5 a
	T3	10.75 b	61.3 b
	T5	6.63 e	30.3 cd
U2.7	T1	11.50 b	65.0 b
	T3	7.95 d	27.9 d
	T5	1.17 f	6.1 e
U3.8	T1	8.95 c	35.1 c
	T3	1.41 f	3.3 ef
	T5	0.00 g	0.0 f
紫外强度U		**	**
照射时间T		**	**
紫外强度×照射时间 U×T		**	**

紫外强度 Ultraviolet intensity/（mW·cm^-2）	照射时间 Irradiation time/min	产孢量 Sporulation yield/（CFU·mL^-1）	抑菌率 Inhibition rate/%
U1.3	T1	842.1 a	29.8 g
	T3	531.5 c	55.7 e
	T5	190.0 f	84.2 b
U2.7	T1	683.3 b	43.1 f
	T3	296.0 e	75.3 c
	T5	125.5 fg	89.6 ab
U3.8	T1	425.7 d	64.6 d
	T3	136.6 fg	88.7 ab
	T5	10.2 g	99.2 a
紫外强度U		**	**
照射时间T		**	**
紫外强度×照射时间 U×T		**	**