Activating Effect and Fertilizer Efficiency of Bio-chemical Combination on Potassium Feldspar

doi:10.13304/j.nykjdb.2021.0410

Abstract

Abstract:

The activation effect of potassium feldspar （K-feldspar） with different dosage and treatment methods were studied by using potassium-solubilizing bacteria （KSB） and activator. The activation mechanism and fertilizer efficiency of biological-chemical combination were explored by X-ray diffraction and corn pot experiment. Different KSB （YC602， YC605 and YC606） combined with activator QN could release water-soluble potassium and available potassium from K-feldspar， and YC602 had the best enhancing effect. YC602 and QN were selected for optimization test， T1 （5%QN+drying at 100 ℃+YC602） and T3 （3%QN+ soaking in water+drying at 200 ℃+YC602） had better activation. Increasing the dosage of activator was beneficial for releasing of water soluble potassium and available potassium.Culture time had little effect on the release of available potassium， while the amount of water-soluble potassium was the best for 24 h. The pot experiment showed that T2A treatment group could effectively promote the growth of maize under the condition of reducing 50% potassium chloride application. Leaching experiment showed that combined technology could effectively reduce the leaching loss of potassium， and the long-lasting fertilizer efficiency. Therefore， bio-chemical combined technology could improve the effectiveness of K-feldspar at normal temperature and pressure， significantly reduce the activation cost， and greatly reduce the potassium chloride consumption， which had the advantages of reduction， efficiency and environmental protection.

Key words: K-feldspar, potassium-solubilizing bacteria, activation, releasing K, corn

摘要：

采用解钾菌和活化剂联用技术，研究不同用量活化剂和处理方式对钾长石的活化效果，通过X射线衍射和玉米盆栽试验探究生物-化学联用的活化机理及其肥效。结果表明，不同解钾菌（YC602、YC605和YC606）与活化剂QN联用对钾长石中水溶性钾和有效钾的释放均有效果，YC602提升效果最佳。选定YC602与QN进行优化试验，其中T1处理（5%QN+100 ℃烘干+YC602）和T3处理（3%QN+水浸泡+200 ℃烘干+YC602）活化效果较好，提高活化剂用量有利于水溶性钾和有效钾的释放。培养时间对于有效钾的释放影响不大，而水溶性钾含量以培养24 h效果最佳。盆栽试验结果表明，减少50%氯化钾施用的条件下，联用技术T2A处理组可有效促进玉米生长。淋溶试验表明，联用技术可有效减少钾素淋溶流失，肥效较持久。联用活化技术在常温常压条件下就可提高钾长石的有效性，明显降低活化成本，并可大幅减少氯化钾用量，具有减量增效和绿色环保的优势。

关键词: 钾长石, 解钾菌, 活化, 钾释放, 玉米

CLC Number:

S143

Xiaoyu LIU, Xixing SHENG, Zongwen LIAO, Lizhen LIN, Kunting LI, Yanfei CAI, Huojun CHEN. Activating Effect and Fertilizer Efficiency of Bio-chemical Combination on Potassium Feldspar[J]. Journal of Agricultural Science and Technology, 2022, 24(7): 132-140.

刘晓玉, 盛锡兴, 廖宗文, 林黎珍, 黎坤婷, 蔡燕飞, 陈火君. 生物-化学联用对钾长石的活化效果及其肥效[J]. 中国农业科技导报, 2022, 24(7): 132-140.

Figures/Tables 13

References 25

1	商照聪,刘刚,包剑. 我国钾资源开发技术进展与展望[J].化肥工业, 2012, 39(4): 5-8, 49.
	SHANG Z C, LIU G, BAO J. Progress and prospect of technology for development of potassium resources in China [J]. J. Chem. Fert. Ind., 2012,39(4): 5-8, 49.
2	熊增华,王石军.中国钾资源开发利用技术及产业发展综述[J]. 矿产保护与利用, 2020, 40(6):1-7.
	XIONG Z H, WANG S J. Overview of potassium resources exploitation ＆ utilization technology and potash industry development [J]. Conservation Utilization Miner. Resour., 2020,40 (6):1-7.
3	陈华丹. NaOH-Na₂CO₃混合亚熔盐介质中钾长石的分解及其综合利用[D]. 福州:福建师范大学, 2017.
	CHEN H D. Decomposition of potassium feldspar in NaOH-Na₂CO₃mixed sub-molten salt and its comprehensive utilization [D]. Fuzhou: Fujian Normal University, 2017.
4	李海龙. 硅酸盐细菌的筛选、鉴定及作用效果的分析[D]. 杨凌:西北农林科技大学, 2011.
	LI H L. Screening, identification and application of silicate bacteria [D]. Yangling: Northwest A&F University, 2011.
5	孙科,耿凤英,于秋菊,等. 牛蒡根际土壤中解钾菌筛选、鉴定及解钾条件优化[J]. 中国酿造, 2020, 39(10): 103-108.
	SUN K, GENG F Y, YU Q J, et al.. Screening and identification of potassium-dissolving bacterium in burdock rhizosphere soil and optomization of potassium-dissolving conditions [J]. China Brewing, 2020, 39(10): 103-108
6	HU X, CHEN J, GUO J. Two phosphate- and potassium-solubilizing bacteria isolated from Tianmu mountain, Zhejiang, China [J]. World J. Microbiol. Biotechnol.,2006, 22(9): 983-990.
7	ZHANG C, KONG F. Isolation and identification of potassium-solubilizing bacteria from tobacco rhizospheric soil and their effect on tobacco plants [J]. Appl. Soil Ecol., 2014, 82: 18-25.
8	SHILPA S, BIHARI R M, INDRA B. Solubilization of potassium containing various K-mineral sources by K-solubilizing bacterial isolates on Aleksandrov Medium [J]. Int. J. Current Microbiol. Appl. Sci., 2018, 7(3): 1142-1151.
9	BAGYALAKSHMI B, PONMURUGAN P, BALAMURUGAN A. Potassium solubilization, plant growth promoting substances by potassium solubilizing bacteria (KSB) from southern Indian Tea plantation soil [J]. Biocatal.Agric. Biotechnol., 2017, 12: 116-124.
10	SETIAWATI T C, MUTMAINNAH L. Solubilization of potassium containing mineral by microorganisms from sugarcane rhizosphere [J]. Agric. Agric. Sci. Procedia, 2016, 9: 108-117.
11	MEENA V S, MAURYA B R. Influence of K-solubilizing bacteria on release of potassium from waste mica [J]. Agric. Sustainable Dev., 2013, 1(1): 53-56.
12	李娜,王其伟,马莹,等. 钾长石制钾肥工艺研究进展[J]. 现代化工, 2020, 40(): 54-58.
	LI N, WANG Q W, MA Y, et al.. Research progress in preparation of potash fertilizers from potash feldspar [J]. Mod. Chem. Ind., 2020, 40(S1): 54-58.
13	李国斌,程东会,王立群. 某难浸金精矿堆浸细菌氧化—氰化浸出试验研究[J]. 黄金,2007(8): 38-41.
	LI G B, CHENG D H, WANG L Q. Experimental research on heap leaching bio-oxidation cyanidation of refractory gold concentrate [J]. Gold, 2007(8): 38-41.
14	BHATTACHARYA S, BACHANI P, JAIN D, et al.. Extraction of potassium from K-feldspar through potassium solubilization in the halophilic Acinetobacter soli (MTCC 5918) isolated from the experimental salt farm [J]. Int. J. Miner. Proc., 2016, 152: 53-57.
15	鲍士旦,史瑞和. 土壤钾素供应状况的研究-Ⅱ.土壤供钾状况与水稻吸钾间的关系[J]. 南京农业大学学报, 1984(4): 70-78.
	BAO S D, SHI R H. Study on the Status of Soil Potassium Supply-‍Ⅱ. the relationship between the status of soil potassium supply and potassium uptake by rice [J]. J. Nanjing Agric.Univ., 1984(4): 70-78.
16	王忠兵,程常占,王广志,等. 钾长石-NaOH体系水热法提钾工艺研究[J]. 化工矿物与加工, 2010, 39(5): 6-7.
	WANG Z B, CHENG C Z, WANG G Z, et al.. Study on extracting potassium from potassium feldspar-NaOH system by hydrothermal method [J]. Ind. Miner. Proc., 2010, 39(5): 6-7.
17	尹卓忻. 铀(Ⅵ)、钍(Ⅳ)在活性白土和钾长石上的吸附研究[D]. 兰州:兰州大学, 2018.
	YIN Z X. Investigations of U and Th sorption on activated bentonite and K-feldspar [D]. Lanzhou:Lanzhou University, 2018.
18	REN X, LI F, CAI Y, et al.. Paenibacillus sp. strain SB-6 induces weathering of Ca-montmorillonite: illitization and formation of calcite [J]. Geomicrobiol. J., 2016, 34(1): 1-10.
19	阮博. 蒙脱石介导鞘氨醇单胞菌GY2B降解菲过程的作用机制研究[D]. 广州:华南理工大学, 2020.
	RUAN B. Mechanism of montmorillonite-mediated biodegradation of phenanthrene by Sphingomonas sp . GY2B [D]. Guangzhou:South China University of Technology, 2020.
20	牛新湘,马兴旺. 农田土壤养分淋溶的研究进展[J]. 中国农学通报, 2011, 27(3): 451-456.
	NIU X X, MA X W. Research advances on leaching of fertilizer nutrients from agricultural soils [J]. Chin. Agric. Sci. Bull., 2011, 27(3): 451-456.
21	梅金飞,刚利萍,余梅霞,等. 烟草秸秆废弃物中纤维素降解菌的筛选、鉴定及产酶条件优化[J]. 烟草科技, 2020, 53(8): 15-23.
	MEI J F, GANG L P, YU M X, et al.. Screening and identification of cellulose-degrading bacteria in waste tobacco stalks and optimization of enzyme production conditions [J]. Tobacco Sci. Technol., 2020, 53(8): 15-23.
22	王明欢,张小娜,林冰,等. 中药药渣中固氮菌、解磷菌、解钾菌的筛选[J]. 中成药, 2020, 42(2): 531-533.
23	狄义宁,刘鲁峰,胡一凡,等. 甘蔗内生菌B9的鉴定及其促生长机制和定殖能力的研究[J]. 中国土壤与肥料, 2019(3): 186-193.
	DI Y N, LIU L F, HU Y F, et al.. Identification of endophytic B9 from sugarcane and its growth-promoting mechanism and colonization ability [J]. China Soils Fert., 2019(3): 186-193.
24	董艳红,王火焰,周健民,等. 不同土壤钾素淋溶特性的初步研究[J]. 土壤, 2014, 46(2): 225-231.
	DONG Y H, WANG H Y, ZHOU J M, et al.. Preliminary study on potassium leaching characteristics of different soils [J]. Soils, 2014, 46(2): 225-231.
25	占丽平,李小坤,鲁剑巍,等. 土壤钾素运移的影响因素研究进展[J]. 土壤, 2012, 44(4): 548-553.
	ZHAN L P, LI X K, LU J W, et al.. Research advances on influence factors of soil potassium movement [J]. Soils, 2012, 44(4): 548-553.

处理Treatment	处理代号Treatment code	处理内容Treatment method
化学活化Chemical activation	C1	5%QN + 钾长石 + 100 ℃烘干 5%QN + K-feldspar + drying at 100 ℃
生物活化Biological activation	B1	钾长石 + YC602 K-feldspar + YC602
	B2	钾长石 + YC605 K-feldspar + YC605
	B3	钾长石 + YC606 K-feldspar + YC606
生物-化学联用 Bio-chemical activation	U1	C1 + YC602
	U2	C1 + YC605
	U3	C1 + YC606

处理Treatment	处理代号Treatment code	处理内容Treatment method
化学活化Chemical activation	C1	5%QN + 钾长石 + 100 ℃烘干 5%QN + K-feldspar + drying at 100 ℃
生物活化Biological activation	B1	钾长石 + YC602 K-feldspar + YC602
	B2	钾长石 + YC605 K-feldspar + YC605
	B3	钾长石 + YC606 K-feldspar + YC606
生物-化学联用 Bio-chemical activation	U1	C1 + YC602
	U2	C1 + YC605
	U3	C1 + YC606

处理Treatment	处理代号Treatment code	处理内容Treatment method
化学活化Chemical activation	CK1	5%QN + 100 ℃烘干 5%QN + drying at 100 ℃
	CK2	3%QN + 100 ℃烘干 3%QN + drying at 100 ℃
	CK3	3%QN + 水浸泡 + 200 ℃烘干 3%QN + water soaking + drying at 200 ℃
生物-化学联用 Bio-chemical activation	T1	CK1 + YC602
	T2	CK2 + YC602
	T3	CK3 + YC602
生物活化Biological activation	T4	YC602 + 钾长石 YC602 + K-feldspar

处理Treatment	处理代号Treatment code	处理内容Treatment method
化学活化Chemical activation	CK1	5%QN + 100 ℃烘干 5%QN + drying at 100 ℃
	CK2	3%QN + 100 ℃烘干 3%QN + drying at 100 ℃
	CK3	3%QN + 水浸泡 + 200 ℃烘干 3%QN + water soaking + drying at 200 ℃
生物-化学联用 Bio-chemical activation	T1	CK1 + YC602
	T2	CK2 + YC602
	T3	CK3 + YC602
生物活化Biological activation	T4	YC602 + 钾长石 YC602 + K-feldspar

处理代号Treatment code	处理内容Treatment method
MCK0	无KCl Without KCl
MCK1	2.28 g钾长石 + YC602 2.28 g K-feldspar + YC602
MCK2	0.5 g KCl
T1A （5%QN）	2.28 g活化钾长石 + YC602 2.28 g activated K-feldspar + YC602
T2A （5%QN）	1.14 g活化钾长石 + 0.25 g KCl + YC602 1.14 g activated K-feldspar + 0.25 g KCl + YC602