Optimization of Extraction Technology and Antifungal Activity of Total Diterpene from Fokienia Hodginsii

doi:10.13304/j.nykjdb.2024.0391

Abstract

Abstract:

To optimize the extraction process of total diterpene from Fokienia hodginsii leaves and antifungal activity， the response surface method was used， and the antifungal activity of total diterpenoids of Fokienia hodginsii leaves against 6 plant pathogenic fungi was investigated by mycelium growth rate method. Colletotrichum gloeosporioides Panz. was used as the test bacterium， and the changes of physiological and biochemical indexes of mycelia and the activity of protective enzymes were further determined to explore the antifungal activity of total diterpene extracts. The results showed that the optimal process conditions were as follows： anhydrous ethanol was used as the extraction solvent， extraction temperature was 79 ℃， extraction time was 53 min， liquid-solid ratio was 14.5 mL∶1 g. Under this condition， the total diterpene yield was 36.8%. The total diterpenoids of Fokienia hodginsii leaves had a good inhibitory effect on Colletotrichum gloeosporioides Panz.， and theEC₅₀ value was 1.466 mg·mL^-1. The dry weight of mycelia of Colletotrichum gloeosporioides Panz. treated with total diterpenoids was significantly decreased， the conductivity was increased， the content of reducing sugar was significantly increased， and the activities of protective enzymes in the fungi increased first and then decreased. Above results laid a foundation for the resource utilization of Fokienia hodginsii leaves.

Key words: Fokienia hodginsii, antifungal activity, EC₅₀, physiology and biochemistry, Colletotrichum gloeosporioides Penz., response surface

摘要：

为优化福建柏叶总二萜提取工艺并研究其抑菌活性，通过响应面法对福建柏叶总二萜提取工艺进行优化，并采用菌丝生长速率法探究福建柏叶总二萜对6种植物病原真菌的抑制活性，以胶孢炭疽菌作为供试菌，进一步对菌丝生理生化指标的变化及保护酶活性进行测定。结果表明，福建柏叶总二萜的最佳工艺条件如下：使用无水乙醇作为提取溶剂，提取温度为79 ℃，提取时间为53 min，液料比为14.5 mL∶1 g。在此条件下，福建柏叶总二萜得率为36.8%。福建柏叶总二萜对胶孢炭疽菌抑制效果较好，EC₅₀值为1.466 mg·mL^-1。经福建柏叶总二萜处理后的胶孢炭疽菌菌丝干重显著降低、电导率升高、还原糖含量显著增加、抗氧化酶活性先升高后降低。以上研究结果为福建柏叶的资源利用奠定基础。

关键词: 福建柏, 抑菌活性, EC₅₀, 生理生化, 胶孢炭疽, 响应面

CLC Number:

S791.43

Shuoshuo FU, Weiyong GONG, Yixuan LIN, Yuanshun LI, Chengcan LIU, Lin NI. Optimization of Extraction Technology and Antifungal Activity of Total Diterpene from Fokienia Hodginsii[J]. Journal of Agricultural Science and Technology, 2025, 27(5): 146-155.

付硕硕, 龚伟勇, 林逸轩, 李渊顺, 刘澄灿, 倪林. 福建柏叶总二萜提取工艺优化及抑菌活性研究[J]. 中国农业科技导报, 2025, 27(5): 146-155.

Figures/Tables 9

References 33

1	DU X M, CHEN X D, REN X L, et al.. The complete chloroplast genome sequence of Fokienia hodginsii (Cupressaceae),an endangered tree [J]. Conserv. Genet. Resour., 2018, 10(4): 813-815.
2	DAO H H T, HOLSCHER D. Fujian cypress and two other threatened tree species in three conservation zones of a nature reserve in north-western Vietnam [J/OL]. For. Ecosyst., 2017, 4(1):9 [2024-04-20]. .
3	林际朗,陈贻谋.福建省主要林木病害名录[J].福建林业科技,1990(1):76-79.
4	WU X D, HE J, LI X Y, et al.. Diterpenoids from the twigs and leaves of Fokienia hodginsii [J]. J. Nat. Prod., 2013, 76(6):1032-1038.
5	周成城,徐文达,陈凌艳,等.福建柏种质资源的保护和利用研究进展[J].亚热带农业研究,2019,15(4):271-278.
	ZHOU C C, XU W D, CHEN L Y, et al.. Research progress on protection and utilization of Fokienia hodginsii germplasm resources [J]. Subtrop. Agric. Res., 2019, 15(4): 271-278.
6	ZHANG Y, FU J R, PAN Z Z, et al.. Chemical constituents from the leaves of Fokienia hodginsii [J].Chem. Nat. Compd.,2023, 59(3): 553-555.
7	邓韵,蔡妙颜,田野,等.溪黄草不同溶剂提取物中总二萜含量的测定[J].现代食品科技, 2005, 21(2): 153-154, 157.
	DENG Y, CAI M Y, TIAN Y, et al.. Determination of diterpenoids in different solvent extraction from Rabdosia serra (Maxim.) Hara [J].Mod. Food Sci. Technol., 2005, 21(2):153-154, 157.
8	周天娇,李春燕,韩莉萍,等.超声辅助提取尾叶香茶菜总二萜工艺研究[J].中医药学报,2018,46(3):77-80.
	ZHOU T J, LI C Y, HAN L P, et al.. Extraction process of total diterpenoids from Rabdosia excise by ultrasonic-assisted extraction method [J]. Acta Chin. Med. Pharmacol., 2018, 46(3):77-80.
9	段志芳,陈庆华.超声波法提取溪黄草中总二萜的最佳工艺研究[J].时珍国医国药,2006(12):2436-2438.
	DUAN Z F, CHEN Q H. Optimum ultrasonic technology in extracting diterpenoids from Rabdosiaseea (Maxim.) Hara. [J]. Lishizhen Med. Materia Medica, 2006(12):2436-2438.
10	马瑞丽,李敏,徐秀泉,等.大孔吸附树脂制备尾叶香茶菜总二萜的工艺研究[J].中成药, 2014, 36(4): 848-851.
11	袁堂丰,瞿利民,郭婕.响应面法优化罗汉松总二萜提取及抗氧化研究[J].中南林业科技大学学报,2019,39(6):114-120, 127.
	YUAN T F, QU L M, GUO J. Response surface methodology for optimization of extracting total diterpenoids from Podocarpus macrophyllus and their antioxidant activity [J]. J.Cent. South Univ. For. Technol., 2019, 39(6):114-120, 127.
12	吴钜文,陈建峰.植物源农药及其安全性[J].植物保护,2002,28(4):39-41.
	WU J W, CHEN J F. Pesticides originated from plants and their safety [J]. Plant Prot., 2002,28(4):39-41.
13	WOO K W, CHOI S U, PARK J C, et al.. A new lignan glycoside from Juniperus rigida [J]. Arch. Pharm. Res., 2011,34(12): 2043-2049.
14	倪林,邱亚铁,李艳蕾,等.HPLC法同时测定闽产圆齿野鸦椿中两种色原酮碳苷的含量[J].林产化学与工业,2018,38(4):103-108.
	NI L, QIU Y T, LI Y L, et al.. Simultaneous determination of isobiflorin and biflorin in Fujian Euscaphis japonica by HPLC [J]. Chem. Ind. For. Prod., 2018, 38(4):103-108.
15	李艳蕾,黄闰玲,邱亚铁,等.圆齿野鸦椿中isobiflorin和biflorin的超声提取工艺[J].福建农林大学学报(自然科学版), 2019, 48(2): 204-209.
	LI Y L, HUANG R L, QIU Y T, et al.. Ultrasonic extraction technology of isobiflorin and biflorin from Euscaphis konishii Hayata [J]. J.Fujian Agric.For.Univ.(Nat.Sci.), 2019,48(2):204-209.
16	张耀,林智熠,周文娟,等.圆齿野鸦椿枝条抗辣椒疫霉病菌活性成分[J].福建农林大学学报(自然科学版),2021,50(4):472-479.
	ZHANG Y, LIN Z Y, ZHOU W J, et al.. Chemical constituents against Phytophthora capsici from twigs of Euscaphis konishii Hayata [J]. J. Fujian Agric.For.Univ.(Nat.Sci.), 2021,50(4):472-479.
17	陈啸,陈源桉,傅钰萍,等.β-香树脂醇对水稻纹枯病菌的抑菌作用[J].亚热带农业研究,2022,18(3):192-197.
	CHEN X, CHEN Y A, FU Y P, et al.. Antifungal effects of β-amyrin against rice sheath blight, Rhizoctonia solani [J]. Subtrop. Agric. Res., 2022, 18(3):192-197.
18	潘镇泽,傅佳蕊,郑威,等.红豆树异黄酮类成分抑制番茄灰霉病菌的活性研究[J].福建农业学报,2022,37(6):794-801.
	PAN Z Z, FU J R, ZHENG W, et al.. Inhibitory activity of isoflavones from Ormosia hosiei seeds against Botrytis cinerea [J]. Fujian J. Agric. Sci., 2022, 37(6):794-801.
19	RATNAWATI D, LUSIAN A, MARTONO A, et al.. Study on the potency of methanol extracts from Xanthosoma nigrum stellfeld as natural antioxidant by thiobarbituric acid method [J/OL]. Aceh Int. J. Sci. Technol., 2014, 2(3):1007 [2024-04-20]. .
20	孟凡国,史红专,王嘉,等.蚂蟥与梨形环棱螺营养成分的相关性研究[J].中国中药杂志,2013,38(12):1915-1918.
	MENG F G, SHI H Z, WANG J, et al.. Correlation analysis between nutritive components of Whitmania pigra and Bellamya purificata [J]. China J. Chin. Mater. Med., 2013,38(12):1915-1918.
21	王江宏,刘艳,桑敏,等.硒对紫球藻抗氧化酶活性及丙二醛含量的影响[J].热带海洋学报,2011,30(3):94-98.
	WANG J H, LIU Y, SANG M, et al.. Effect of selenium on antioxidant enzyme activity and malondialdehyde content of Porphyridium sp [J]. J. Trop. Oceanogr., 2011, 30(3):94-98.
22	沈文飚,徐朗莱,叶茂炳,等.氮蓝四唑光化还原法测定超氧化物歧化酶活性的适宜条件[J].南京农业大学学报,1996,19(2):101-102.
	SHEN W B, XU L L, YE M B, et al.. The suitable conditions for determining SOD activity by nitro blue trtrazolium (NBT) photoreduction method [J]. J. Nanjing Agric. Univ., 1996, 19(2):101-102.
23	LI W, FU J R, ZHENG L J, et al.. Two new bibenzyls from Pleione grandiflora (Rolfe) Rolfe and their antioxidant activity [J]. Nat. Prod. Res., 2023,37(15):2486-2492.
24	WU M T, WU X Q, ZHENG L J, et al.. Discovery of glucosyloxybenzyl 2-hydroxy-2-isobutylsuccinates with anti-inflammatory activities from Pleione grandiflora [J/OL].Fitoterapia, 2021,155:105062 [2024-04-20]. .
25	曹付威,刘福林,任莹莹,等.益母草二萜类化合物的提取工艺及其抑菌活性[J].山东第一医科大学(山东省医学科学院)学报,2021,42(10):739-743.
	CAO F W, LIU F L, REN Y Y, et al.. Eextraction technology of diterpenoids from Leonurus japonicas and its antimicrobial activity[J]. J. Shandong First Med. Univ. Shandong Acad. Med. Sci., 2021, 42(10):739-743.
26	袁堂丰.罗汉松化学成分分离及抑制酪氨酸酶活性研究[D].吉首:吉首大学,2019.
	YUAN T F. Isolation on chemical constituents from Podocarpus macrophllus and their tyrosinase inhibition activity [D]. Jishou: Jishou University,2019.
27	魏晴,郑双,何兰凤,等.响应面法优化米槁叶片黄酮的提取工艺[J].化学工程师,2022,36(7):84-88, 62.
	WEI Q, ZHENG S, HE L F, et al.. Response surface methodology to optimize the extraction process of flavonoids from Cinnamomum migao H.W.Li leaves [J]. Chem. Eng., 2022, 36(7): 84-88, 62.
28	陈雁雁,赵雅兰,张淑香,等.Box-Behnken响应面法优化柴胡多糖的超声提取工艺[J].化学工程师,2022,36(2):71-75, 81.
	CHEN Y Y, ZHAO Y L, ZHANG S X, et al.. Optimize the ultrasonic extraction process of Bupleurum polysaccharides by Box-Behnken response surface method [J]. Chem.Eng., 2022,36(2):71-75, 81.
29	XIE Z Q, DING L F, WANG D S, et al.. Sesquiterpenes from the leaves of Magnolia delavayi franch.and their cytotoxic activities [J/OL]. Chem. Biodivers., 2019, 16(5):e1900013 [2024-04-20]. .
30	闫海燕.砂地柏中具杀虫活性的二萜类及香豆素类化合物的分离[D].杨凌:西北农林科技大学,2007.
	YAN H Y. Study on onsecticidal activety of diterpenoids and coumarins fromSabina vulgaris Ant. [D]. Yangling:Northwest A&F University, 2007.
31	杨婷,史红安,李聪丽,等.13种萜类化合物对胶孢炭疽菌和链格孢的抑制活性[J].植物保护,2017,43(2):192-195.
	YANG T, SHI H A, LI C L, et al.. Antifungal activity of 13 terpenoid compounds against Colletotrichum gloeosporioides and Alternaria sp [J]. Plant Prot., 2017, 43(2):192-195.
32	丁兰,何苗,王保强,等.4种萜类化合物对蝴蝶兰茎腐病菌的抑制作用及机理的初步研究[J].植物保护,2014,40(3):42-47, 57.
	DING L, HE M, WANG B Q, et al.. Antibacterial activity and related mechanism of four terpenoids on the pathogen of Phalaenopsis amabilis stem rot [J]. Plant Prot., 2014, 40(3):42-47, 57.
33	LEONORA M, SEPúLVEDA C, RICARDO M, et al.. Characterization of the antifungal activity against botrytis cinerea of sclareol and 13-epi-sclareol, two labdane-type diterpenoids [J]. J. Chil. Chem. Soc., 2015, 60(3):3024-3028.

水平 Level	因素Factor
水平 Level	A：时间 Time/min	B：温度 Temperature/℃	C：液料比 Liquid-solid ratio/（mL·g^-1）
-1	50	75	10∶1
0	60	80	15∶1
1	70	85	20∶1

水平 Level	因素Factor
水平 Level	A：时间 Time/min	B：温度 Temperature/℃	C：液料比 Liquid-solid ratio/（mL·g^-1）
-1	50	75	10∶1
0	60	80	15∶1
1	70	85	20∶1

编号 Serial number	A：时间 Time/min	B：温度 Temperature/℃	C：液料比 Liquid-material/（mL·g^-1）	得率 Yield/%
1	70	85	15∶1	26.28
2	60	80	15∶1	37.20
3	60	80	15∶1	36.66
4	60	80	15∶1	36.18
5	60	75	20∶1	25.20
6	60	75	10∶1	30.72
7	60	85	20∶1	24.60
8	50	75	15∶1	29.82
9	50	80	10∶1	28.68
10	70	75	15∶1	31.08
11	60	80	15∶1	35.94
12	50	80	20∶1	28.68
13	50	85	15∶1	28.56
14	60	80	15∶1	36.72
15	70	80	20∶1	24.78
16	60	85	10∶1	24.00
17	70	80	10∶1	27.90

编号 Serial number	A：时间 Time/min	B：温度 Temperature/℃	C：液料比 Liquid-material/（mL·g^-1）	得率 Yield/%
1	70	85	15∶1	26.28
2	60	80	15∶1	37.20
3	60	80	15∶1	36.66
4	60	80	15∶1	36.18
5	60	75	20∶1	25.20
6	60	75	10∶1	30.72
7	60	85	20∶1	24.60
8	50	75	15∶1	29.82
9	50	80	10∶1	28.68
10	70	75	15∶1	31.08
11	60	80	15∶1	35.94
12	50	80	20∶1	28.68
13	50	85	15∶1	28.56
14	60	80	15∶1	36.72
15	70	80	20∶1	24.78
16	60	85	10∶1	24.00
17	70	80	10∶1	27.90

方差来源 Source of variation	平方和 Sum of squares	自由度 df	均方 Mean square	F值 F value	P值 P value	显著性 Significance
模型Model	352.02	9	39.11	84.25	<0.000 1	**
A	4.06	1	4.06	8.75	0.021 2	*
B	22.38	1	22.38	48.20	0.000 2	**
C	8.08	1	8.08	17.40	0.004 2	*
AB	3.13	1	3.13	6.75	0.035 5	*
AC	2.43	1	2.43	5.24	0.055 8
BC	9.36	1	9.36	20.17	0.002 8	*
A²	40.79	1	40.79	87.86	<0.000 1	**
B²	84.98	1	84.98	183.04	<0.000 1	**
C²	147.44	1	147.44	317.57	<0.000 1	**
残差Residual	3.25	7	0.46
失拟Lack of fit	2.28	3	0.76	3.12	0.149 9
纯误差Pure error	0.97	4	0.24
总计Total	355.27	16